Product ID:BUTYL RUBBER CAULK, C-110
MSDS Date:11/01/1995
FSC:8030
NIIN:00N018640
MSDS Number: CGZNV

SHERWIN-WILLIAMS CO

101 PROSPECT AVE
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: DO642

SHERWIN-WILLIAMS CO THE SPECIALTY DIV.

6709 SOLON, OH 44139-3908 US

Telephone: 216-292-7400

Cage: DO642

2

CAS: 64742-88-7

Fraction By Weight: 13%

OSHA PEL 100 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL 0.2 FIBERS/CC

ACGIH TLV: 0.2 FIBER/CC, A1

1); (CALCIUM CARBONATE)

CAS: 471-34-1

RTECS: FF9335000

Fraction By Weight: 57%

OSHA PEL N/K

ACGIH TLV: N/K

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 1%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

& SPRAY MIST. AVOID CONT W/SKIN & EYES. THIS

RTECS: 9999999ZZ

PARTICULATES (LISTED "AS DUST") WHICH MAY BE PRESENT

RTECS: 9999999ZZ

DRIED FILM. IF NO SPECIFIC DUSTS ARE LISTED, THE

RTECS: 9999999ZZ

(TOTAL DUST), OSHA PEL 15 MG/M3 (TOTAL DUST), 5

RTECS: 9999999ZZ

OSHA STANDARDS 1910.94, 1910.107, 1910.108.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & UPPER
RESP SYS. IN CONFINED AREA VAPS IN HIGH CONC MAY CAUSE HDCH,
NAUS/DIZZ. SIGNS & SYMPS OF OVEREXP: HDCH, DIZZ, NAUS, & LOSS OF
COORDINATION ARE INDICATIONS OF EXCESS EXPOS TO VAPS/SPRAY MISTS.
REDNESS & ITCHING/BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN
EXPOSURE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: PRLNGD OVEREXP TO SOLV
INGREDIENTS MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYSTEMS. RATS
EXPOS TO TITANIUM DIOXIDE DUST @ 250 MG/M3 DEVELOPED LUNG CANCER,
HOWEVER, SUCH EXPOS LEVE LS ARE NOT ATTAINABLE IN WORKPLACE. RPTS
HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS
DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHAL: IF ANY BRTHG PROBLEMS OCCUR DURING USE, LEAVE AREA &
GET FRESH AIR. IF PROBLEMS REMAIN/OCCUR LATER, IMMED GET MED ATTN.
SKIN: WASH AREA THOROUGHLY W/SOAP AND WATER. EYES: FLUSH WITH LARGE
AMOUN TS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST: GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT. ELEC EQUIP, SPKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLIC TO HOT SURFS (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURECES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT & OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING &
GROUNDING PROCS. KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
INTENTIONAL MISUSES BY DELIB CONC & INHALING CONTENTS CAN BE
HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAPOR (ING 6)

Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPRVD BY NIOSH FOR DUST WHICH MAY BE
GENERATED FROM PROD, UNDERLYING PAIN T, OR THE ABRASIVE.
Ventilation:LOC EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO MATLS
IS MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER TO (ING 10)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLOSION WHEN
EXPOS TO EXTREME HEAT. EXPLO HAZ: REQS SPEC PRECAUTIONS. DURING
EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZARD. SYMPS MA
Y NOT BE IMMED APPARENT. OBTAIN MED ATTN. WASTE DISP METH:
REGARDING POLLUTION.

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.58
VOC Grams/Liter:1.73
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:27

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC
EPA HAZ WASTE NUMBERS. INCINERATE IN APPRVD FACILITY. DO NOT
INCINERATE CLSD CNTNR. DISPOSE I/A/W FED, STATE, & LOCAL REGS
(SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.